flare part Articles

  • Greenstars portable monitoring for CHP and flares

    Greenstar’s award-winning KTK landfill site in Kilcullen, Co. Kildare, is unusual in Ireland in that it has three gas engines feeding electricity to the grid and two flares. In Ireland, while flaring is common, engines are not. The flares are run in tandem with engines so that if an engine is ramped down for repair or service, the flare ramps up automatically. All are supplied by 122 ...

  • Greenstars portable monitoring for CHP and flares case study

    Greenstar's award-winning KTK landfill site in Kilcullen, Co. Kildare, is unusual in Ireland in that it has three gas engines feeding electricity to the grid and two flares. In Ireland, while flaring is common, engines are not. The flares are run in tandem with engines so that if an engine is ramped down for repair or service, the flare ramps up automatically. All are supplied by 122 landfill gas ...

  • Hofstetter high temperature flares in Brazil (CO2 certificates)

    Type      HOFGAS®- Efficiency 2500 (2x)  Commissioning      2003 Site      Bandeirantes(Saõ Paulo, BR)    Situation The landfill of Saõ Paulo, the largest city in South America, extends over 140 ha. For a period of 4 more years several thousands tons of waste will be deposited. The power ...


    By Hofstetter BV

  • U.S. EPA Proposes Substantial Refinery Flare Operating and Monitoring Requirements

    U.S. EPA is proposing to amend the operating and monitoring requirements for flares at petroleum refineries.  The proposed revisions are complex and are far reaching, and if promulgated, will affect all flares at petroleum refineries.  U.S. EPA’s stated rationale for the proposed revisions is that the ...


    By All4 Inc.

  • Measurement of Sulfur in Refinery Flare Gas Streams for Compliance with EPA SubpartJ(a) Regulations

    The Challenge Measurement of high range and low range H,S in refinery flare gas streams for compliance with EPA regulation NSPS Subpart J(a). The rule has placed an extra investment and operational burden on petroleum refineries to meet the regulatory requirement. AMETEK offers an economical solution to meet the challenge with an emphasis on lower capital and operating cost along with ...

  • Tech Note: Flare Gas Measurement Innovation; Retain Flow Metering Accuracy Even if Gas Composition Changes

    It’s a fact oil wells almost always produce natural gas along with the petroleum. Nine times out of ten, the excess gas (typically hydrocarbons) is flared off or simply vented as-is during upset conditions in the process. The environmental impacts of “flaring” this excess gas into our atmosphere has resulted in government regulations like 40 CFR Part 60 Subpart OOOO (also ...


    By Sierra Instruments, Inc.

  • Biomass gassing as an effective source of energy

    Type     HOFGAS®- IFM4c 4000/2100 Performance     2100 Nm3/h / 3500 kW          Location     Limoges (FR) Situation A prestigious gassing plant for biomass is being built in the heart of France. The owner is promising himself a significantly higher level of efficiency through ...


    By Hofstetter BV

  • Energy Savings on Process Heating Units Case History

    The Customer This specialty chemical company is a leading supplier of performance polymers. Their products are used in a wide range of applications including adhesives, coatings, consumer and personal care products, sealants, lubricants, medical, packaging, automotive, paving, roofing and footwear products. The Project The company was increasing the ...

  • Solution concepts for the production of biogas

    With its products that go to form part of biogas plants, it is not only a significant pioneering role that Hofstetter Umwelttechnik AG in Switzerland deserves. The company in Berne also adopts a leading position on the worldwide market for utilizing biogas. Hofstetter products – the socalled flares and compressor stations – are designed both for fermentation plants for biomass and for plants for ...


    By Hofstetter BV

  • Oil Chiefs Clash over Energy and Climate

    Conflicting messages about how the oil industry should respond to climate change and manage its reputation have been sent out by the heads of three oil majors - ExxonMobil, Shell and ChevronTexaco. None foresees a challenge to the supremacy of oil and gas for the next three decades - but on many other issues the transatlantic rift runs deep. ExxonMobil remains the target for a global campaign by ...

  • Case study - Keeping ethanol production green

    OVERVIEW Originally published in Pollution Engineering Magazine. In an effort to reduce the world’s dependence on fossil fuels, there has been a major push towards alternatives. Ethanol has been at the forefront of this movement because it reduces greenhouse gas emissions from automobiles and its production has a positive net energy balance. The homegrown fuel also ...

  • Microturbines, Gas Engines Link Biogas to the Grid

    OPPORTUNITIES to produce electricity from methane are being improved continuously as manufacturers introduce new and upgraded equipment to address market needs and varying characteristics of raw biogas. In the renewable energy from organics recycling arena, the two primary types of electricity generation equipment are microturbines and reciprocating gas engines. This article provides a brief ...


    By BioCycle Magazine

  • What`s New? Biogas Power

    Technologies that connect the biogas line to the power line include cooling and clean up components, microturbines and reciprocating gas engines and control systems. TOP BILLING on the biogas to electricity stage typically goes to the microturbines and reciprocating gas engines. But in the theater of renewable energy from organics recycling, the show can’t go on without the supporting cast of gas ...


    By BioCycle Magazine

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you