flaring application Articles

  • Greenstars portable monitoring for CHP and flares

    Greenstar’s award-winning KTK landfill site in Kilcullen, Co. Kildare, is unusual in Ireland in that it has three gas engines feeding electricity to the grid and two flares. In Ireland, while flaring is common, engines are not. The flares are run in tandem with engines so that if an engine is ramped down for repair or service, the flare ramps up automatically. All are supplied by 122 ...

  • Assist Gas Measurement in Flare Stacks

    The Customer The company manufactures solvents, polymers and intermediary chemicals. These products are sold worldwide and are used in the production of automobile interiors, steering wheels, paints, tires, adhesives, furniture, cosmetics and many other consumer and industrial products. The Process The Company’s site is large, thousands of acres, ...

  • Greenstars portable monitoring for CHP and flares case study

    Greenstar's award-winning KTK landfill site in Kilcullen, Co. Kildare, is unusual in Ireland in that it has three gas engines feeding electricity to the grid and two flares. In Ireland, while flaring is common, engines are not. The flares are run in tandem with engines so that if an engine is ramped down for repair or service, the flare ramps up automatically. All are supplied by 122 landfill gas ...

  • Stacking up: flare Monitoring from LumaSense

    Lenny Shaver, LumaSense Technologies’ director of product management, explains the company’s IR and pyrometer technologies FLARING systems are common in many industries to burn gases before they enter the atmosphere. The safe operation of a flaring system requires the continuous monitoring of pilot flames and flared gases to ensure that vented gases are ignited. As ...

  • Extended exergy accounting applied to the flaring practice in oil fields

    An original procedure based on the Extended Exergy Accounting method is described and implemented in this paper. The goal is the quantification of the environmental externality linked to the chemical pollutants released by an elevated flare stack (SOx and NOx). The extended exergy calculations provide a measure of both the exergy flux ...


    By Inderscience Publishers

  • U.S. EPA Proposes Substantial Refinery Flare Operating and Monitoring Requirements

    U.S. EPA is proposing to amend the operating and monitoring requirements for flares at petroleum refineries.  The proposed revisions are complex and are far reaching, and if promulgated, will affect all flares at petroleum refineries.  U.S. EPA’s stated rationale for the proposed revisions is that the ...


    By All4 Inc.

  • Measurement of Sulfur in Refinery Flare Gas Streams for Compliance with EPA SubpartJ(a) Regulations

    The Challenge Measurement of high range and low range H,S in refinery flare gas streams for compliance with EPA regulation NSPS Subpart J(a). The rule has placed an extra investment and operational burden on petroleum refineries to meet the regulatory requirement. AMETEK offers an economical solution to meet the challenge with an emphasis on lower capital and operating cost along with ...

  • Tech Note: Flare Gas Measurement Innovation; Retain Flow Metering Accuracy Even if Gas Composition Changes

    It’s a fact oil wells almost always produce natural gas along with the petroleum. Nine times out of ten, the excess gas (typically hydrocarbons) is flared off or simply vented as-is during upset conditions in the process. The environmental impacts of “flaring” this excess gas into our atmosphere has resulted in government regulations like 40 CFR Part 60 Subpart OOOO (also ...


    By Sierra Instruments, Inc.

  • Oil refinery application case study

    This case study illustrates an application on an oil refinery. Main Reasons for use: Increase efficiency of production Reduce water consumption Reduce excess flaring of gases Background Fushun Oil Refinery No.2 is located in NE China. Fushun has 2 medium sized oil refineries both have installed Wap-Flaro for ...

  • Energy Savings on Process Heating Units Case History

    The Customer This specialty chemical company is a leading supplier of performance polymers. Their products are used in a wide range of applications including adhesives, coatings, consumer and personal care products, sealants, lubricants, medical, packaging, automotive, paving, roofing and footwear products. The Project The company was increasing the ...

  • Assessing Feasibility of Direct Drive Technology for Energy Recovery from Digester Biogas

    ABSTRACTThe Regional Municipality of Waterloo completed a study, with support from Environment Canada, to evaluate the feasibility of using direct drive technology to recover energy from digester biogas. The study identified that a 150 HP engine, operating at 54 % load, could be supported by the estimated gas production of 1560 m3/d with 63 % methane by volume. ...

  • Biomethane enters the gas grid article for energy world

    The Carbon Plan, published in 2011, aims to reduce UK carbon emissions by a quarter from 1990 levels. With the current policies in place, the UK is on target to reduce emissions by over a third by 2020 and with the introduction of new technologies this should increase to an 80% reduction by 2050. However, currently around half the UK’s carbon emissions result from heat related processes and ...


    By CNG Services Limited

  • High-strength wastes boost biogas production

    Water and wastewater treatment plants (WWTP) are significant consumers of energy. The U.S. Environmental Protection Agency estimates the industry uses the equivalent of 56 billion kilowatt hours (kWh) of electricity, representing three percent of the nation’s energy consumption, and is responsible for creating 45 million tons of greenhouse gas emissions each year. Energy intensive processes, such ...


    By BioCycle Magazine

  • Oil Chiefs Clash over Energy and Climate

    Conflicting messages about how the oil industry should respond to climate change and manage its reputation have been sent out by the heads of three oil majors - ExxonMobil, Shell and ChevronTexaco. None foresees a challenge to the supremacy of oil and gas for the next three decades - but on many other issues the transatlantic rift runs deep. ExxonMobil remains the target for a global campaign by ...

  • Cenovus brings new approaches to emissions and energy management across 1,000 facilities

    Cenovus Energy is proud of being a new company with new ideas and new approaches. This Canadian oil company began independent operations in December 2009 and is committed to using fresh, progressive thinking to safely and responsibly unlock energy resources the world needs. Its operations include oil sands projects in northern Alberta that use specialized methods to bring oil to the surface. It ...


    By IHS Markit

  • National brewery benefits from biogas

    Anheuser-Busch has installed anaerobic digestion systems at 10 of its 12 large breweries in the U.S., with an 11th system in design. Primary drivers are cost-avoidance for wastewater treatment fees and fossil fuel purchases. ANHEUSER-BUSCH, owner of 12 large breweries in the U.S., has committed to reduce its greenhouse gas emissions 5 percent from 2005 levels by 2010. The company is well ...


    By BioCycle Magazine

  • Microturbines, Gas Engines Link Biogas to the Grid

    OPPORTUNITIES to produce electricity from methane are being improved continuously as manufacturers introduce new and upgraded equipment to address market needs and varying characteristics of raw biogas. In the renewable energy from organics recycling arena, the two primary types of electricity generation equipment are microturbines and reciprocating gas engines. This article provides a brief ...


    By BioCycle Magazine

  • What`s New? Biogas Power

    Technologies that connect the biogas line to the power line include cooling and clean up components, microturbines and reciprocating gas engines and control systems. TOP BILLING on the biogas to electricity stage typically goes to the microturbines and reciprocating gas engines. But in the theater of renewable energy from organics recycling, the show can’t go on without the supporting cast of gas ...


    By BioCycle Magazine

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you