high temperature boiler Articles

  • Saving waste in the boiler house

    Burner technology has improved greatly in recent years. Older Burners had a series of cams and levers that were calibrated to provide specific amounts of air for a particular rate of firing. Being mechanical items, these wore and sometimes required calibration. They, therefore, had to be regularly serviced and calibrated. Generally, new burners use frequency controlled motors and cams to open air ...


    By EBE Engineering Ltd.

  • Attention to the use of steam boilers in the industry

    In the industry, if people need to use high-temperature steam , then the steam boiler will be used; water can be heated to a quite high temperature, and generates high-temperature steam . Steam boilers and other hot water boiler are not the same , if people want to use the steam boiler, the boiler must be certified , or else once operated wrongly , then the consequences are very terrible.  ...

  • Chemically Inclined: The Case for Clean Boilers

    Boiler cleaning is something most companies don’t want to think about — if boilers are working within operational limits it’s often easier to keep up with smaller preventative maintenance (PM) tasks but put off a total chemical clean ...

  • 10 ton CFB Power Plant Boiler

    This type of boilers is very popular in recent years. ...


    By ZGZhengzhou boiler

  • Lister housing cooperative - condensing boiler case study

    Customer: Lister Housing Cooperative Location: Lauriston Place, Edinburgh Heating System: New Vaillant Condensing System Boiler Installed: 02/09 The property is a two bedroom flat in a Georgian terrace with high ceilings and hard to heat. Before hand the flat was not heated properly even after ...


    By Vortex Energy Saver

  • How to improve the combustion efficiency of biomass fired steam boiler

    Biomass fired steam boiler,like other industrial boilers,needs to improve its combustion efficiency to realize energy conservation.Zhengzhou Boiler Co., Ltd,as an experienced biomass fired steam boiler manufacturer in China,gives the following advices to improve the combustion efficiency of biomass fired ...


  • Lister housing cooperative - non condensing boiler case study

    Customer: Lister Housing Cooperative Location: Lauriston Place, Edinburgh Heating System: Potterton Suprima 24KW Non Condensing Boilerinstalled in 1991. Installed: 02/09 Lister Housing Association carried out a trial on Vortex. The property is a 6 bed 3 storey Georgian terrace with high ...


    By Vortex Energy Saver

  • 1×30MW and 2×15MW power plant boilers, which will be much better

    1×30MW, 2×15MW power plants boiler which will be much better According to our discussion in some forum with some experts and our real experiences, it is founded that two sets of 15MW is much more better than the former in many aspects: I. One boiler can operate normally if the fuel is not enough for two boilers. However, for one sets 30MW boiler, we have to lower the working rate on ...


  • Fine particle capture in biomass boilers with recirculating gas cyclones: Theory and practice

    This paper addresses the theoretical development and experimental validation of optimized recirculating reverse-flow gas cyclones. The simulation of these systems is based on the predictive properties of a finite diffusivity model, modified to include partial recirculation of the cyclones' emissions. Experimental validation was obtained at laboratory and pilot scales at low temperatures (up to ...

  • High-strength wastes boost biogas production

    Water and wastewater treatment plants (WWTP) are significant consumers of energy. The U.S. Environmental Protection Agency estimates the industry uses the equivalent of 56 billion kilowatt hours (kWh) of electricity, representing three percent of the nation’s energy consumption, and is responsible for creating 45 million tons of greenhouse gas emissions each year. Energy intensive processes, such ...


    By BioCycle Magazine

  • Why the High End Of An Oven Steam Cleaner Is In Demand At Restaurants, Hotels, and Bakeries?

    People who clean ovens using traditional methods have to scrub, scrape, and wipe for a long time before they can say that the oven is just a little bit cleaner than before. However, partial cleanliness is not enough. Big ovens are mostly used in commercial areas, such as restaurants and bakeries, where hygiene norms must be strictly followed. To stay on the right side of sanitation laws, you have ...


    By Daimer Industries Inc.

  • Recyclone MH to Reduce Particulate Matter from a biomass boiler burning a mixture of mesocarp fibre and palm kernel shell (137 620 m3/h at 320ºC) - Case Study

    Foreword Advanced Cyclone Systems, S.A. (ACS) designed and supplied a Hurricane Cyclone System for Tradewinds Plantation Management SDN BHD in Malaysia, with the objective of reducing Particulate Matter (PM) emitted by a Palm Waste Boiler from 500mg/Nm3 to less than 150mg/Nm3. ...

  • Catalytic combustion of fuels and existing ways for its implementation

    The new technology of flameless high-temperature combustion of fuel on the basis of catalytic method has the advantages consisting of the ecological cleanliess of process, the growth of volume thermal stress of furnace space and the reduction of specific quantity of metal and boiler cost. Application of catalytic boiler plants allows to bring in the maximum produced heat to the customers. Thus, ...


    By Inderscience Publishers

  • First industrial application of an open absorption cycle for heat transformation in a district-heating network

    The first plant for high temperature utilisation of higher heating value was realised under industrial conditions in a combined heat and power plant. The technology results in an increased heat recovery temperature and a stronger dehumidification of the flue gas. Beyond that, the use of large solution flow within an adiabatic absorber enables to combine gas scrubbing and dehumidifying. Economic ...


    By Inderscience Publishers

  • Ottawa Hospital, Ottawa Heart Institute, Ottawa, Ontario, Canada

    Boiler Plant Application Objective The turnkey FLU-ACE waste heat recovery system was installed by Thermal Energy on four boiler exhausts from a power plant which produced a peak (winter) steam rate of 70,000 lbs/h. The system was designed to recover 10 mmBTU/h of otherwise wasted energy. The recovered heat is used to heat the the world-famous University of Ottawa Heart Institute ...

  • Case study - Waste heat generates steam and savings

    OVERVIEW A coil coating facility purchased a new a 15,000 SCFM Regenerative Thermal Oxidizer (RTO) which had a nominal heat transfer efficiency rate of 90% thermal energy recovery. It was designed with supplemental fuel injection (SFI) which is used during low VOC loading conditions, to help save fuel cost.  The facility was looking for additional ways to decrease their exhaust ...

  • Window Cleaning Equipment for Sparkling Clean Interiors

    Window cleaning equipment that are versatile and offer powerful cleaning are in great demand. Commercial window cleaning requires contractors to use equipment that clean quickly and with minimum fuss. Some of the features of high quality window cleaning machines are mentioned below: Clean Glass without Scratching Most obsolete cleaning tools scratch or otherwise damage ...


    By Daimer Industries Inc.

  • Allready-Box brings security to production of bioenergy

    Animal feed manufacturer Futtertrocknung Mindelheim eG of southern Germany has been operating a co-generation power station since 2008. During the summer months, this power station uses ecological methods to generate the heat and electricity the company needs to dry soilage. Utilizing a year-round, low-temperature heating network, it supplies local industrial firms and public institutions with ...


    By ALLWEILER GmbH

  • Performance assessment of a 5 kW SOFC cogeneration fuel cell

    The performance of a 5 kW Solid Oxide Fuel Cell (SOFC) will be studied and described in this paper. This will help to significantly reduce residential Green House Gas (GHG) emission to about 20%, when compared with the actual emissions, based on the high-performance boiler and electricity produced by high-efficiency combined cycle. The particular benefit of SOFC, when compared with other ...


    By Inderscience Publishers

  • Overview of mercury control in coal-fired power plants

    During combustion, the mercury (Hg) in coal is volatilized and converted to elemental mercury (Hg0) vapor in the high temperature regions of coal-fired boilers. As the flue gas is cooled, a series of complex reactions begin to convert Hg0 to ionic mercury (Hg2+) compounds and/or Hg compounds (Hgp) that are in a solid-phase at flue gas cleaning temperatures or Hg that is adsorbed onto the surface ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you