low emission flare Articles

  • Performance of the low-emission flare

    Job report / Elbisgraben (Bale / Switzerland) The summer of 1992 had finally arrived. The 5MW low emission furnace in the district heating station Liestal was ignited, supplied with landfill gas from Elbisgraben landfill. Since then the plant has been running continuously and the comprehensive measurements taken, verify that all targets aimed at have been achieved: plant ...


    By Hofstetter BV

  • 1:60 Control Range with Flare

    Type     HOFGAS®- LPM 3000/2500  Performance     2,500 Nm³/h, 12,500 kW Location     Central England (GB) Initial Situation The landfill site is situated in the middle of the Sheffield region. Over time, the city limits and the landfill site have grown together. Therefore, the operator is particularly ...


    By Hofstetter BV

  • Flare Operations Changes Come From Study Findings

    EPA announced that it had reached a settlement agreement with Marathon Petroleum Company (Marathon) regarding allegations of Clean Air Act violations at Marathon’s Texas City and Detroit refineries. EPA developed the evidence by Fourier Transform Infrared Spectroscopy (FTIR) showing that several of Marathon’s flares were not controlling VOC emissions sufficiently, ...

  • Case study: AMAPETCO onshore gas power generation

    ProServe with its principles Dresser Rand has supplied, installed, commissioned and start up on Nov 2015 a very unique 2 X 780 kW gas gen sets using the flare gas at AMAPETCO company field in Ras Eldeb bay “100 Km south of Hurghada city on the red sea. These two gen sets are the first environmental friendly ones in Egypt using a catalytic convertor to reduce the NOx to less than 100 ppm. ...


    By ProServe Egypt

  • Enisei oil production facility

    Capitalizing on previously flared gas Oil production is a well established industry in Russia. Enisei Ltd is an oil business situated in the town of Usinsk, Komi Republic, Russia. The company’s core business is oil production at the oil field located 60 km North of Usinsk. Full utilization of APG is not a widely spread practice in Russia. In general, complete utilization of ...


    By Camco Clean Energy Company

  • Case study - Agiba Gas Power Generation

    Proserve has recently carried out a power generation project with Agiba Petroleum Company in the western desert of Egypt to utilize the waste free flare gas instead of the very expensive fossil diesel fuel to power the oil production wells ‘pumps. The project faced several technical challenges. The associated gas has a low methane number” less than 45”,  which necessitated ...


    By ProServe Egypt

  • Energy Savings on Process Heating Units Case History

    The Customer This specialty chemical company is a leading supplier of performance polymers. Their products are used in a wide range of applications including adhesives, coatings, consumer and personal care products, sealants, lubricants, medical, packaging, automotive, paving, roofing and footwear products. The Project The company was increasing the ...

  • Removal of ecologically harmful pyrolysis gas and vapours

    Type     HOFGAS®- IFM4c/1000 Commissioning     August 2002 Site     Waste water treatment plants Situation As a result of new authority requirements, Romag AG set up operation of a plant for the drying and gasification of wastewater sludge. Drying vapours are formed during the sludge drying and pyrolysis gas during gasification. These emissions must be burned in an ecological way, ...


    By Hofstetter BV

  • Case study - Grand Junction Sets the Pace with Colorado’s First Biogas-to-Vehicle Fuel Project at the Persigo Wastewater Plant

    The first biogas-to-vehicle fuel project in Colorado converts wastewater-derived biogas mto renewable natural gas (RNG) to fuel city and county fleet vehicles Summary: The Per si go wastewater treatment plant in Grand Junction, Colorado, a city of about 60,000, processes upwards of 8.2 million gallons per day of wastewater in two anaerobic digestion tanks (primary and ...


    By Energy Vision

  • Case study - Keeping ethanol production green

    OVERVIEW Originally published in Pollution Engineering Magazine. In an effort to reduce the world’s dependence on fossil fuels, there has been a major push towards alternatives. Ethanol has been at the forefront of this movement because it reduces greenhouse gas emissions from automobiles and its production has a positive net energy balance. The homegrown fuel also ...

  • Biomethane enters the gas grid article for energy world

    The Carbon Plan, published in 2011, aims to reduce UK carbon emissions by a quarter from 1990 levels. With the current policies in place, the UK is on target to reduce emissions by over a third by 2020 and with the introduction of new technologies this should increase to an 80% reduction by 2050. However, currently around half the UK’s carbon emissions result from heat related processes and ...


    By CNG Services Limited

  • Symphony Of The Microgrid At An Urban University

    Perched on the wind-sculpted bluffs above the Pacific Ocean, the University of California San Diego (UCSD) is one of the world’s leading research universities, with an average R&D budget of $1 billion in each of the last three years. Research includes over 50 years of investigating climate change at UCSD’s Scripps Institution of Oceanography, making it no surprise that the ...


    By BioCycle Magazine

  • Oil Chiefs Clash over Energy and Climate

    Conflicting messages about how the oil industry should respond to climate change and manage its reputation have been sent out by the heads of three oil majors - ExxonMobil, Shell and ChevronTexaco. None foresees a challenge to the supremacy of oil and gas for the next three decades - but on many other issues the transatlantic rift runs deep. ExxonMobil remains the target for a global campaign by ...

  • Microturbines, Gas Engines Link Biogas to the Grid

    OPPORTUNITIES to produce electricity from methane are being improved continuously as manufacturers introduce new and upgraded equipment to address market needs and varying characteristics of raw biogas. In the renewable energy from organics recycling arena, the two primary types of electricity generation equipment are microturbines and reciprocating gas engines. This article provides a brief ...


    By BioCycle Magazine

  • High-strength wastes boost biogas production

    Water and wastewater treatment plants (WWTP) are significant consumers of energy. The U.S. Environmental Protection Agency estimates the industry uses the equivalent of 56 billion kilowatt hours (kWh) of electricity, representing three percent of the nation’s energy consumption, and is responsible for creating 45 million tons of greenhouse gas emissions each year. Energy intensive processes, such ...


    By BioCycle Magazine

  • Will natural gas dim solar’s shine?

    As natural gas booms, renewable energy proponents ponder whether it will serve as a bridge or roadblock to photovoltaic power On the outskirts of downtown St. Paul, Minn., Xcel Energy’s High Bridge Generating Station offers an iconic view of the current state of electrical generation in the United ...


    By Ensia

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you