7 products found
Ennox Biogas Technology GmbH Products
-
Gas Treatment - Purification
Raw biogas is good, purified biogas is even better. Gas purification means that after different kind of cleaning procedures, the gas is prepared for an energetic or material use. Raw biogas is produced in biogas plants and contains different kind of gases as well as water and foam- or contamination particles. The same applies to sewage gas and landfill gas. Ennox supplies the required equipment for separation of the dust, foam particles and condensation water, such as gravel filter, ceramic fine filter, condensate pot, sediment pot and gas chill dryer. For removing chemical contamination like H2S and siloxane a biological desulphurisation and an active carbon filter can be used.
-
Ennox carboNOX - Active Carbon Filter
Biogas can contain large quantities of poisonous hydrogen sulphide depending upon the fermentation process and which input materials are used. This gas can cause permanent damage to gas engines or other consumers of the biogas. Depending on concentration, the majority of the hydrogen sulphide gas can be effectively removed by using an ennox active carbon ...
-
Ennox - Model CFP - Ceramic Fine Filter
Before the coarse filtered bio or sewage gas can be fed to the gas consumer it is normally passed through a ceramic fine fillter. Here the gas is passed through a ceramic or reclay unit with a pre-determined pore diameter. Fine particles < 150 – 210 μm and condensate vapour are effectively removed. This eliminates any possible damage to components further on in the gas processing line. A variety of filter materials and filter sizes can be ...
-
Ennox - Model COA - Condensate Accumulator
The condensate accumulator is used for both the collection of condensate water within the gas system and for drainage. Normally the condensate accumulator is integrated directly into the lowest point of the pipework by means of a flange connection. The condensate water flows into the collection container and is drained either through a ball valve, or automatically with a condensate drainage unit. The condensate accumulator is available in two sizes, ...
-
Ennox - Model COP - Condensate Pot
The condensate pot serves for the removal of condensate vapour or water occurring in the gas system. The gas flows through the condensate pot where it is channelled within the pot through a separation chamber. The reduction in gas flow velocity and the influence of temperature fluctuations cause the water vapour in the gas to condense and collect at the bottom of the pot. The condensate pot can be delivered in various sizes according to the capacity of ...
-
Ennox - Model GCD - Gas Chill Dryer
Biogas, sewage gas and land fill gas contains not only water vapour, but also a whole host of additional impurities such as hydrogen sulphide, NH3 and siloxane, which, when processed in the utilization system can not only lead to a reduction in efficiency, but also result in damage of the ...
-
Ennox - Model GFR - Gravel Filter
The gravel filter enables the coarse filtration of the biogas by passing through a gravel layer. Foreign particles, foam and condensate are removed and channelled to a drainage point. The filter can be easily accessed through a screwed cover for cleaning. Contamination can be easily removed without the need for opening the cover by rinsing with water. The gravel filter is available for various volume flow rates and pressures. As an option we provide ...
-
Ennox - Model SET - Sediment Trap
The sediment trap removes sediment particles or condensate water which may accumulate in the gas system. The contaminated and/or saturated gas is set into a spiral motion within the container by a special inlet nozzle. The heavier particles and water collect on the side walls of the unit, where they then accumulate at the bottom of the container. Drainage can be achieved either manually or automatically. The units are available in various sizes with ...