Flares Articles
-
Regional development company monitoring system for Methane gas flaring site - Case Study
The project includes collecting and burning Methane gas- Methane is the primary component of natural gas – a common fuel source. Crystal Vision developed an Upgrade of the gas collection and burning system through remote control and alarm system as part of the reduction of greenhouse gases emitted in the landfill sites of the garbage from the Arava and Eilat. ...
-
Multipoint systems measure flare gases – Case Study
To mitigate greenhouse gas emissions, many companies reuse their biogas for cogeneration, but the amount of biogas produced often exceeds the amount needed for cogeneration. In such cases, it is often not economical to purify, compress and store the gas for later use, so it is flared off. Accurate mass flow instrumentation is essential for these companies to comply with the new EPA ...
-
Modification of Competition - Designed Enclosed Combustor - Case Study #170402
Project Details Location: Rosa, CA & Dexter, MI Max Heat Release: 2.4 MMBTU/HR Application: Food Services (Brewery) Customer purchased a flare system designed by a competitor, and upon installation, determined that they had issues lighting the burner. Detailed analysis of the design revealed that the burner design was not appropriate for the application. AEREON’s Service & ...
-
High Temperature Flare (HTF) - Case Study #170605
PROJECT DETAILS Location: Beaumont, TX Product Loaded: Gasoline Max RVP: 10.20 PSIA @ 109 °F Max Liquid Loading Rate: 7,000 GPM Max Inlet Flow Rate: 52,087 ACFH Rated Heat Release : 81 MMBTU/HR Max VOC Concentration: 45% Inlet Temperature: 100°F MAX Aereon’s Abutec HTF (High Temperature Flare) is designed to maintain high destruction efficiency and removal efficiency, ...
-
VC-08/VC-06 Momentum Series Dual HP & LP Sentinel - Case Study #170401
PROJECT DETAILS Location: East Texas Flow Rate HP: 5.0MMSCFD HP Inlet Pressure(ΔP): <1psig Flow Rate LP: 300MSCFD LP Inlet Pressure(ΔP): 2oz/in2 Heating Value: 1,600 BTU/SCF Pilot: Q-50 Smokeless: Up To Ringelmann1 Installed Year: 2017 On an East Texas, mature oil well, AEREON provides smokeless operation, for heavy vapors, at very low flows and pressures, without ...
-
Cyclone Series Air Assisted Flare With Model 850 Flamex Ignition System - Case Study #170604
Project Details Location: Freeport, TX Max Inlet Flow Rate: 12,765 lbs/hr Smokeless Flow Rate: 0 ‐ 100% of Max Flow, Meets Ringelmann1 Molecular Weight: 58.30 Flare Gas LHV: 3013 Btu/SCF Required Inlet Pressure: 12 psig Inlet Temperature: 80 F Aereon’s Air assist flare system with model 850 Flamexignition system is used in this case in Freeport, TX to dispose of heavier ...
-
Model 435 Hurricane Pilot (Design & Field Testing) - Case Study #170404
Project Details Location: Ferndale, WA Flow Rate: 75 MBTU/HR Set Pressure: 10-15 psig Fuel Source: Natural Gas Design Wind Speed: >130 MPH On a steam assist flare near the coast, provided by Aereon in 2013, the client reported repeated issues with pilot outages and exciter failures for the installed Model 255 pilots. Frequent rain storms and damp salt air resulted in these ...
-
Momentum Series HP-1500 (4” X 25’) High Pressure Flare - Case Study #170206
PROJECT DETAILS Location:Permian Basin Flow Rate HP: 1.7 MMSCFD HP Inlet Pressure (ΔP): 50-75 PSIG Smokeless %: 100% Pilot & Controls: ProFire1300 Solar Package: No ElectricyRequired Installed Year:2017 Aereon’s Momentum Series, Unassisted Flare is used to burn off waste natural gas from a high-pressure separator. The technology used for this flare design allows for 100% ...
-
Ghost Series & Momentum Series Combo AB-20 Combustor / HP-1500 Flare - Case Study #170203
Project Details Location: Permian Basin Flow Rate HP: 1.5 MMSCFD HP Inlet Pressure (ΔP): 50-75 PSIG Flow Rate LP: 20.0 MSCFD LP Inlet Pressure (ΔP): 4 oz/in.2 Smokeless %: 100% Pilot & Controls: ProFire 2100 & 1300 Solar Package: No Electricity Required Installed Year: 2017Installed Year: 2017 Aereon’s Ghost/Momentum Combo Package (EPA Certified for Quad O ...
-
Guardian VRU Cold Temperature Electric VRU - Case Study #170304
Project Details Location: Bakken Flow Rate: 342 MSCFD Inlet Pressure: 3-6 oz. Discharge Pressure: 85 psig Specific Gravity: 1.97 Power: 75 HP Gas Source: Tank Vapors Installed Year: 2017 Aereon’s Guardian Series Cold Weather VRU has been utilized in the Bakken shale play now for 7 years. Located in the heart of oil country and able to handle the extreme low temperatures of ...
-
HP1500/HP3000 Flares - Case Study #170101
Project Details Location: Pecos, TX Flow Rate : 5 MMscfd Inlet Pressure(ΔP): 20psi Aereon’s HP series flares are used to burn high pressure waste gas at multiple flow rates. Customer used multiple flares along with a combustor to be able to accommodate high and low pressures coming from multiple sources. The integral skid design reduces installation costs and has a minimal ...
-
Cyclone Series SFVP-0824 X 40’ Air Assist Flare - #170301
Project Details Location: Permian Basin Flow Rate: 12MMSCFD HP Inlet Pressure (ΔP): 10-30 psig Heating Value: 2300 BTU/SCF Installed Year: 2017 Aereon’s Cyclone Series Air Assist flare won a 6 vendor “shoot out” to become the preferred flare for a major producer in the Permian Basin. Aereon was selected due to the large flow rate, high turn down and extremely ...
-
Inferno Series TGA-662 X 30’ Gas Assisted Flare - Case Study #170305
PROJECT DETAILS Location: Bakken Flow Rate: 6.18 MSCFD Inlet Pressure (ΔP): 1.52 psig Heating Value: 1000 BTU/SCF Flare type: Gas Assist Source: Tank Vapors Installed Year: 2010-2017 Aereon’s Inferno series Gas Assisted flare has been in use for over 7 years in the Bakken Shale play. Located in the heart of oil country and able to handle the extreme low temperatures of North Dakota, ...
-
Ghost Series AB-200 x 20’ Enclosed Flare - Case Study #170302
PROJECT DETAILS Location: Somerset, CO Heat Capacity: 18.4 MMBTU/hr Inlet Pressure (ΔP): 6” WC Heating Value: ~300 BTU/SCF AB-200: 490 MSCFD Carbon Credits: $6000/ day Installed Year: 2017 Aereon’s Ghost series enclosed flare is pictured here on a Coal Bed Methane operation in Somerset Colorado. Harmful Methane was being vented to the atmosphere from an abandoned ...
-
Cyclone Series MAVP 0616 x 25’ Air-Assist Elevated Flare - Case Study #170105
PROJECT DETAILS Location: PayneCounty, OK Flow Rate LP: 1.5MMSCFD LP Inlet Pressure(ΔP): 8-10oz/in2 Heating Value: 2351 BTU/SCF Blower: 5 HP VS Info: Midstream Client Aereon’s Cyclone Series Air Assist flare is used to maintain emission compliance by destroying condensate tank vapors at a Gathering System’s Compressor Station. The system is designed for normal and ...
-
Fully Enclosed Flare FEF-48 Vapor Combustion Unit - Case Study #170501
PROJECT DETAILS Location: Appalachian Basin/Utica Max. Capacity: 7.0 MMBTU/hr LHV: 1100BTU/SCF Pilot Gas: 65 SCFH of Nat. Gas @10-15 PSIG Purge Gas: 13 SCFH Electrical: 50-60 Hz/120 VAC, 60 Hz/ 480 VAC Blower Aereon’s Fully Enclosed Flare (FEF) as seen here is located in the Utica Shale play in the Appalachian Basin and is being used to combust tank vapors at a truck loading ...
-
Cyclone Air-Assist Flares SFVP-0824 X 40’ - Case Study #170204
Project Details Location: Permian Basin Flow Rate HP: 10 MMSCFD HP Inlet Pressure (ΔP): 10-250 psig HP Smokeless %: 100% of flow Flow Rate LP: 1.0 MMSCFD LP Inlet Pressure (ΔP): 8 oz/in2 LP Smokeless %: 100% of flow Heating Value: 1250 BTU/SCF Pilot: Electronic Model 850 Installed Year: 2017 Aereon’sCyclone Series Air-Assisted Flare is used here to burn off ...
-
CEB 800 CA Enclosed Flare System - Case Study #170104
Project Details Location: Oxnard,CA FlowRate: 25.7MMBTU/HR InletPressure: >1psig Heating Value: 1220 BTU/SCF INFO: Oil Production Tank Vapors INFO: BACT required by AQMD INFO: Expansion to 39MMBTU/HR Aereon’sCertified Ultra Low Emissions Burner (CEB) technology is Best Available Control Technology (BACT) approved for Air Quality Management Districts (AQMD) throughout ...
-
Flare Monitoring Quasar 2 – a new generation of Infrared pilot flame monitors from LumaSense
LUMASENSE Technologies, a provider of temperature and gas sensing devices, has introduced its next generation F2T Quasar 2 Continuous Flare Stack Monitoring System for pilot flames and flared gases. Ihe scalability of the new flare monitoring systems and Iheir ability to inlegrale multiple monitoring technologies through software allow for a flare monitoring solution for all the market, ...
-
ASHCOR Hires Industry Veteran Mike Diehl
ASHCOR’s newest sales manager, Mike Diehl, is an oil and gas veteran with over 30 years of experience in the oil and natural gas industry. Diehl is well-versed in technical sales and business management and his skillset and industry knowledge will help give ASHCOR customers a trustworthy and personalized sales experience. As Sales Manager, Diehl will oversee business development efforts for ...
By ASHCOR
Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you