Gas Desulfurization Articles

  • Biogas Plant - Case Study

    The first unit of the integrated system at the Gonen Renewable Energy Complex consists of a state of the art biogas plant. Our biogas plant, which achieves the highest capacity utilization rate in Turkey, both generates electricity and produces raw materials for the CatLiq and Organic Fertilizer ...


    By Altaca Energy

  • Danish Biogas plant preparing for dynamic FeCl2 dosing Case Study

    The operator of a Danish biogas plant is preparing to start dynamic FeCl2 dosing to cost-optimise the plant’s 3-stage desulphurisation process. Measuring in the wet and unprocessed biogas right after an anaerobic digester, a SulfiLoggerTM H2S sensor provides continuous H2S data, enabling the operator to adjust the injection rate of FeCl2 to ...

  • Organic Power's Largest GWE RAPTOR Plant Makes A Compelling Case For Proven Clean-Energy Biotechnology

    Clean energy specialists Organic Power Ltd have chosen to install one of the largest ever GWE RAPTOR anaerobic biological transformation energy crop/ waste-to-energy plants at their new green energy facility in Vega Baja, Puerto Rico. ...


    By Global Water & Energy

  • Fly Ash & the Lightweight Aggregate Market

    In 2015, the global fly ash market was estimated to be valued at 40 billion USD. A recent industry analysis by Research Nester anticipates the market will reach an estimated 70 billion USD by the end of 2023 – a 7.1% CAGR owing to increasing ...


    By FEECO International, Inc.

  • Resource treatment of HPF coking desulphurisation waste solution: composition and characteristics of pyrolysis

    HPF (H: hydroquinone; P: dinuclear cobalt-phthalocyanine sulfonate; F: ferrous sulphate) coking desulphurisation waste solution (CDWS) produced from coking oven gas desulphurisation process is an extremely harmful pollutant. The fundamental natures of this solution, which involves its main ingredient and content, type of organic matter, thermal decomposition characteristics of salt, and ...


    By Inderscience Publishers

  • The MBR for biological desulfurization of biogas the BioReactor with the DMT BioSulfurex HCP process

    Abstract DMT has developed a process for biological desulfurization at low pH for the treatment of biogas. This process (BioSulfurex®) is pH, temperature, nutrient and oxygen controlled. During an intensive research period the elimination capacity (EC) and removal efficiencies (RE) at different process conditions were determined. The effect of variations in H2S loading, cleaning procedures ...

  • Hydrogen sulfide removal from livestock biogas by a farm-scale bio-filter desulfurization system

    A farm-scale biogas desulfurization system was designed and tested for H2S removal efficiency from livestock biogas. This work assesses the H2S removal efficiency of a novel farm-scale biogas bio-desulfurization system (BBS) operated for 350 days on a 1,000-head pig farm. Experimental data demonstrated that suitable humidity and temperature can help sulfur-oxidizing bacteria to form ...


    By IWA Publishing

  • Case study: Maabjerg Bioenergy

    Substrate: Animal manure and food waste Biogas flow: 3.600 Nm3/h H2S Inlet: 3.000 ppm H2S Outlet: 80 ppm Year of installation: 2012 The Maabjerg plant is a collaboration between agriculture, municipalities and the district heat station and is situated in the northern part of Denmark. When in full ...


    By Biogasclean A/S

  • Case study: Roager Bioenergi

    Substrate: Energy crops, animal manure, other organic material Biogas flow: 1.200 Nm3/h H2S inlet: 2.000 ppm H2S H2S outlet: 50 ppm H2S Year of Installation: 2011 Roager/Lundsby Bioenergi is located in the southern part of Denmark. It is a unique biogas plant as the input is a mixture of animal ...


    By Biogasclean A/S

  • Case study: GFE Krogenskær A/S

    Substrate: Animal Manure & co-digestion Biogas flow: 1.200 Nm3/h H2S inlet: 3.000 ppm H2S outlet: 10 ppm Year of installation: 2010 The BioGascleaner was installed at Krogenskær as a replacement of another H2S filter which collapsed due to the normal H2S and biogas flow fluctuations of the ...


    By Biogasclean A/S

  • Coal Fired Boiler two-stage flue gas desulfurization (FGD)

    A major pulp and paper mill located in New England, USA was faced with a control order to reduce SO2 and a schedule challenge to meet the order deadline and steam requirements. In addition, the customer was looking for ways to save reagent cost. Macrotek was selected to design and build two wet FGD systems for two 100,000 lbs/hr medium sulfur coal fired boilers. The design included a two-stage ...


    By Macrotek Inc.

  • Determination of the optimal rate for the microaerobic treatment of several H2S concentrations in biogas from sludge digesters

    The treatment of H2S in the biogas produced during anaerobic digestion has to be carried out to ensure the efficient long-lasting use of its energetic potential. The microaerobic removal of H2S was studied to determine the treatment capacity at low and high H2S concentrations in the biogas (0.33 and 3.38% v/v) and to determine the optimal O2 rate that achieved a concentration of H2S of 150 mg/Nm3 ...


    By IWA Publishing

  • Portable biogas bottling plant: a practical approach for using biogas as transportation fuel in rural areas

    Biogas contains about 65% methane, 30-35% carbon dioxide, traces of hydrogen sulphide and moisture. It has been observed that diesel engines get severely damaged when operated on biogas for long duration. Presence of these corrosive gases make biogas unsuitable for transportation application. By removing CO2 and trace acidic gases like H2S and moisture, biogas can be converted into natural gas ...


    By Inderscience Publishers

  • Biolimp siloxa for plant for biogas cleaning

    The biogas produced in a digester, landfill or waste water plant is normally treated in order to remove water, H2S, dust and/or CO2. The choice of the cleaning method employed and the compound to be removed depends on the type of end use of the gas. This paper focuses on desing, star up and operation of biogas cleaning plant for removal dangerous component (water, H2S, NH3, siloxane and ...


    By Energy & Waste S.l

  • Cost Effective Desulfurization of Gas Streams

    The LO-CAT® II process provides cost effective H2S removal for all types of gas streams in many different industries. The LO-CAT and LO-CAT II processes have achieved H2S removal efficiencies of 99.9+% in many different applications and industries. These applications include natural gas production, oil refining, biogas, landfill gas, coke oven gas, geothermal steam power production, CO2 ...


    By Merichem Company

  • Biogas desulphurisation using the DMT multiple stage Sulfurex® process

    Global rising energy costs are focusing efforts by many industrial and municipal entities to find new sources of energy. Generating electricity from Biogas is of course nothing new however the cost of cleaning up certain Biogas streams with excessive levels of Hydrogen Sulphide (H2S) has previously proven to be financially unsustainable. Rising energy costs combined with improvements and cost ...

  • Present status and future prospect of clean coal technology in China

    Coal consumption accounts for about two thirds of the primary energy consumption in China. High economic growth has brought about a rapid increase of coal consumption. Low-efficiency combustion of a large amount of coal caused coal-smoke related air pollution. The Chinese government put forward plans to develop clean coal technology in the early 1990s, and has listed it as one of the emphases for ...


    By Inderscience Publishers

  • Experience curves for power plant emission control technologies

    This paper examines past experience in controlling emissions of sulphur dioxide (SO2) and nitrogen oxides (NOx) from coal-fired electric power plants. In particular, we focus on US and worldwide experience with two major environmental control technologies: flue gas desulphurisation (FGD) systems for SO2 control and selective catalytic reduction (SCR) ...


    By Inderscience Publishers

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you