Steam Boilers Brochure

Steam BoilersWritten by AdministratorThursday, 12 November 2009 14:02 - Last Updated Saturday, 14 November 2009 12:23 Waste Heat Recovery Systems are designed for pressure drop on exhaust gas side as permaximum permissible back pressure of source equipment. Adequate margin for rise in pressure drop in Waste Heat Recovery System due to soot accumulation is provided to prolongthe time between two successive cleaning operations.     It is well known that Waste Heat Recovery System has large potential savings in fuel cost forthe fired equipment. Payback period is very attractive. Optimized thermal design (with economizer for Boilers) ensures maximum heat recovery fromexhaust gases. The heating surface of the system is provided with adequate margin for fouling on exhaust gasside. This ensures that heat recovery is not affected by soot accumulation on tubes withinreasonable limits. Design Boilers designs for individual client’s requirements, heat recovery boilers can be horizontal or 1 / 3Steam BoilersWritten by AdministratorThursday, 12 November 2009 14:02 - Last Updated Saturday, 14 November 2009 12:23vertical, fire tube or water tube and single or two pass. Boilers are designed for easy maintenance and repair as per ASME codes. Refractory lined where required and 80 to 160 Kg Rock wool jacketed with M.S. Color Sheet orS.S. sheet where required. Mountings - Pressure Relief Valves - Manual Air Vent - Pressure Gauge - Low Water Cut-off - Pressure Switches - Pressure Transducer - Sensors - Valves Electric Panel Pre wired control and instrument panel with all operating and safety controls of boiler isprovided, in case of safety operation boiler goes on bypass mode and audible alarm operatesand indicator lights. Following indications, monitoring, operational and safeties are available onpanel. - Power ON/OFF switch and light indicator - Low water level indicator - Hi flue gas temperature indicator - Flue gas inlet temperature indicator 2 / 3Steam BoilersWritten by AdministratorThursday, 12 November 2009 14:02 - Last Updated Saturday, 14 November 2009 12:23 - Flue gas outlet temperature controller - Water inlet temperature indicator - Steam Pressure controller - Manual / Auto mode switch and indicators 3 / 3