utility flare Articles

  • Performance of the low-emission flare

    Job report / Elbisgraben (Bale / Switzerland) The summer of 1992 had finally arrived. The 5MW low emission furnace in the district heating station Liestal was ignited, supplied with landfill gas from Elbisgraben landfill. Since then the plant has been running continuously and the comprehensive measurements taken, verify that all targets aimed at have been achieved: plant ...


    By Hofstetter BV

  • Biomass generation facility replaces flare - Case study

    A southeast-based Biomass Generation facility was interested in improving their current process to meet California’s increasingly stringent air emission requirements. At the time, a flare was being used to oxidize the off-gases from various production processes and storage containers. Catalytic Products International developed a solution that utilized the capabilities of the VECTOR ...

  • Case study - Environmentally friendly vapor combustors, flares and incinerators

    Today’s industry requires innovative, cost competitive solutions to meet the ever growing and changing needs in the market. ABUTEC has developed a full line of “Environmentally Friendly” Vapor Combustors, Flares and Incinerators to meet these demands. The HTF (High Temperature Flare) and MTF (Medium Temperature Ground Flare) offer a flexible and scalable solution to clients in a ...


  • Measurement of Sulfur in Refinery Flare Gas Streams for Compliance with EPA SubpartJ(a) Regulations

    The Challenge Measurement of high range and low range H,S in refinery flare gas streams for compliance with EPA regulation NSPS Subpart J(a). The rule has placed an extra investment and operational burden on petroleum refineries to meet the regulatory requirement. AMETEK offers an economical solution to meet the challenge with an emphasis on lower capital and operating cost along with ...

  • Enisei oil production facility

    Capitalizing on previously flared gas Oil production is a well established industry in Russia. Enisei Ltd is an oil business situated in the town of Usinsk, Komi Republic, Russia. The company’s core business is oil production at the oil field located 60 km North of Usinsk. Full utilization of APG is not a widely spread practice in Russia. In general, complete utilization of ...


    By Camco Clean Energy Company

  • Small scale biogas upgrading: Green gas with the DMT Carborex® MS system

    Abstract  More and more effort is being put in the utilization of bio-solids. Bio-solids can be an important source for useful products like fertilizers and biogas. DMT has been developing biogas treatment plants for over 20 years following the market developments closely.  Biogas was first seen as a nuisance at e.g. landfills, creating odor problems and methane emissions. A flare has ...

  • Case study - Agiba Gas Power Generation

    Proserve has recently carried out a power generation project with Agiba Petroleum Company in the western desert of Egypt to utilize the waste free flare gas instead of the very expensive fossil diesel fuel to power the oil production wells ‘pumps. The project faced several technical challenges. The associated gas has a low methane number” less than 45”,  which necessitated ...


    By ProServe Egypt

  • Assessing Feasibility of Direct Drive Technology for Energy Recovery from Digester Biogas

    ABSTRACTThe Regional Municipality of Waterloo completed a study, with support from Environment Canada, to evaluate the feasibility of using direct drive technology to recover energy from digester biogas. The study identified that a 150 HP engine, operating at 54 % load, could be supported by the estimated gas production of 1560 m3/d with 63 % methane by volume. ...

  • Solution concepts for the production of biogas

    With its products that go to form part of biogas plants, it is not only a significant pioneering role that Hofstetter Umwelttechnik AG in Switzerland deserves. The company in Berne also adopts a leading position on the worldwide market for utilizing biogas. Hofstetter products – the socalled flares and compressor stations – are designed both for fermentation plants for biomass and for plants for ...


    By Hofstetter BV

  • Case study - Grand Junction Sets the Pace with Colorado’s First Biogas-to-Vehicle Fuel Project at the Persigo Wastewater Plant

    The first biogas-to-vehicle fuel project in Colorado converts wastewater-derived biogas mto renewable natural gas (RNG) to fuel city and county fleet vehicles Summary: The Per si go wastewater treatment plant in Grand Junction, Colorado, a city of about 60,000, processes upwards of 8.2 million gallons per day of wastewater in two anaerobic digestion tanks (primary and ...


    By Energy Vision

  • Symphony Of The Microgrid At An Urban University

    Perched on the wind-sculpted bluffs above the Pacific Ocean, the University of California San Diego (UCSD) is one of the world’s leading research universities, with an average R&D budget of $1 billion in each of the last three years. Research includes over 50 years of investigating climate change at UCSD’s Scripps Institution of Oceanography, making it no surprise that the ...


    By BioCycle Magazine

  • High-strength wastes boost biogas production

    Water and wastewater treatment plants (WWTP) are significant consumers of energy. The U.S. Environmental Protection Agency estimates the industry uses the equivalent of 56 billion kilowatt hours (kWh) of electricity, representing three percent of the nation’s energy consumption, and is responsible for creating 45 million tons of greenhouse gas emissions each year. Energy intensive processes, such ...


    By BioCycle Magazine

  • National brewery benefits from biogas

    Anheuser-Busch has installed anaerobic digestion systems at 10 of its 12 large breweries in the U.S., with an 11th system in design. Primary drivers are cost-avoidance for wastewater treatment fees and fossil fuel purchases. ANHEUSER-BUSCH, owner of 12 large breweries in the U.S., has committed to reduce its greenhouse gas emissions 5 percent from 2005 levels by 2010. The company is well ...


    By BioCycle Magazine

  • Biogas Market Snapshot 2014

    1. Biogas Market Scope - Introduction and Definition Biogas is a widely available renewable energy source that can produce uninterrupted baseload power. Biogas can be produced from a wide variety of available organic materials and wastes, including sewage sludge, animal manure, municipal/industrial organic waste, stillage from ethanol production, crop residues, and specially grown energy ...


    By XPRT Media

  • Will natural gas dim solar’s shine?

    As natural gas booms, renewable energy proponents ponder whether it will serve as a bridge or roadblock to photovoltaic power On the outskirts of downtown St. Paul, Minn., Xcel Energy’s High Bridge Generating Station offers an iconic view of the current state of electrical generation in the United ...


    By Ensia

  • What`s New? Biogas Power

    Technologies that connect the biogas line to the power line include cooling and clean up components, microturbines and reciprocating gas engines and control systems. TOP BILLING on the biogas to electricity stage typically goes to the microturbines and reciprocating gas engines. But in the theater of renewable energy from organics recycling, the show can’t go on without the supporting cast of gas ...


    By BioCycle Magazine

  • Microturbines, Gas Engines Link Biogas to the Grid

    OPPORTUNITIES to produce electricity from methane are being improved continuously as manufacturers introduce new and upgraded equipment to address market needs and varying characteristics of raw biogas. In the renewable energy from organics recycling arena, the two primary types of electricity generation equipment are microturbines and reciprocating gas engines. This article provides a brief ...


    By BioCycle Magazine

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you